filename: tfs 208b.doc version 1.5 05.08.2005 vi telefilter filter specification tfs 208b 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. measurement condition ambient temperature: 23 c input power level: 0 dbm terminating impedance: * input: 50 ? output: 50 ? characteristics remark: the reference level for the relative attenuation a rel of the tfs 208b is the maximu m attenuation in the pass band. the maximum attenuation in the pass band is defined as the insertion loss a e . the nominal frequency f n is fixed at 208 mhz without any tolerance or limit. the values of relative attenuation a rel are guaranteed for the whole operating temper ature range. the frequency shift of the f ilter in the operating temperature range is included in the production tolerance scheme. d a t a typ. value tolerance / limit insertion loss a e 2,2 db 1,5 ?3,5 db (reference level) - - nominal frequency f n - 208 mhz bandwidth bw 1 db 4,9 mhz 800 khz relative attenuation a rel f n - 400 khz ? f n + 400 khz 0,15 db max. 1 db f n - 207 mhz f n - 28 mhz 57 db min. 38 db f n - 28 mhz f n - 14 mhz 48 db min. 30 db f n + 14 mhz f n + 28 mhz 37 db min. 5 db f n + 28 mhz f n + 242 mhz 45 db min. 12 db absolute group delay f n - 400 khz ? f n + 400 khz 180 ns max. 300 ns group delay ripple *) f n - 400 khz ? f n + 400 khz 8 ns max. 30 ns vswr f n - 400 khz ? f n + 400 khz 1,3 : 1 max. 2 : 1 intermodulation **) ip3 min. 45 db input power level max. 10 dbm operating temperature range otr - - 10 c ... + 85c storage temperature range - - 40 c ... + 125c temperature coefficient of frequency tc f ***) - 36 ppm/k *) measured with smoothing; smoothing aperture 50 khz **) modulation signals: f n and f n + 14 mhz, each of 10 dbm; measured signal: f n - 14 mhz ***) ? f(hz) = tc f (ppm/k) x ( ? t) x f to (mhz) generated: checked / approved:
filename: tfs 208b.doc version 1.5 05.08.2005 vi telefilter filter specification tfs 208b 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. filter characteristic construction and pin connection (all dimensions in mm) 9,3 max. 5,0max. 1 2 3 4 5 6 7 8 9 10 1,8 max. 7,1 2,54 0,1 0,10 0,8 2,8 2,54 0,1 2,54 0,1 6 0 1 2 3 4 5 6 7 8 9 10 date code 50 ? test circuit l1 saw l 2 10 5 1, 2, 3, 4, 6, 7, 8, 9 tfs 208b t31 1 ground 2 ground 3 ground 4 ground 5 output 6 ground 7 ground 8 ground 9 ground 10 input date code: year + week t 2005 u 2006 v 2007 ... 10 58 106 154 202 250 298 346 394 442 490 -100 -90 -80 -70 -60 -50 -40 -30 -20 -10 0 frequency in mhz magnitude in db 204 204.8 205.6 206.4 207.2 208 208.8 209.6 210.4 211.2 212 -10 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 frequency in mhz magnitude in db 204 204.8 205.6 206.4 207.2 208 208.8 209.6 210.4 211.2 212 0.15 0.16 0.17 0.18 0.19 0.2 0.21 0.22 0.23 0.24 0.25 frequency in mhz delay in s
filename: tfs 208b.doc version 1.5 05.08.2005 vi telefilter filter specification tfs 208b 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. stability characteristics after the following tests the filter shall meet the whole specification: 1. shock: 500g, 1 ms, half sine wave, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely, 1 octave per min, 10 cycles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cycles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; packing tape & reel: iec 286 ? 3, with exeption of value for n and minimum bending radius; tape type ii, embossed carrier tape with top cover tape on the upper side; max. pieces of filters peer reel: 3000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao pull off direction pin marker typ date code ko t a c n w 1 w 2 the minimum bending radius is 45 mm. tape (all dimensions in mm) w : 16,00 +0,3/-0,1 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 7,50 0,1 g(min) : 0,60 p2 : 2,00 0,1 p1 : 8,00 0,1 d1(min) : 1,50 ao : 5,30 0,1 bo : 9,70 0,1 ct : 13,5 0,1 reel (all dimensions in mm) a : 330 w1 : 16,4 +2/-0 w2(max) : 22,4 n(min) : 50 c : 13,0 +0,5/-0,2
filename: tfs 208b.doc version 1.5 05.08.2005 vi telefilter filter specification tfs 208b 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. air reflow temperature conditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c between 300 and 600 seconds > 150c between 240 and 500 seconds > 217c between 30 and 150 seconds peak temperature max. 260c time within 5c of actual peak temperature between 10 and 30 seconds cool-down rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds temperature / c time / s max. 260c 217c 10 ... 30 s 30 ... 150 s max. 300 s chip-mount air reflow profile
filename: tfs 208b.doc version 1.5 05.08.2005 vi telefilter filter specification tfs 208b 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. recommended land dimensions history version reason of changes name date 1.0 - generate according to customer r equirement specification dr. sabah 22.11.2000 1.1 - stopband attenuation corrected steiner 23.11.2000 1.2 - change the high frequency side trans ition band edge frequency steiner 30.11.2000 f0+13,5mhz ? f0+14mhz 1.3 - change the specification to customer updated specification version 1.0.0 (16-05-2001) dr. sabah 30.05.2001 1.4 - change trailer to 300mm dr. sabah 04.07.2001 1.5 - change packing and mark pin1 of pin connection strehl 05.08.2005 - correct recommended land dimensions
|
